实验方法与实验动物 EXPERIMENTAL METHOD AND ANIMAL

解淀粉芽孢杆菌实时荧光定量PCR测定方法的建立及其在豆粕发酵中的应用

  • 杨湘黔 ,
  • 崔京春 ,
  • 曾诗娴 ,
  • 成丽 ,
  • 张珂彬 ,
  • 胡晓红 ,
  • 鲍雅静
展开
  • 1. 大连民族大学生命科学学院, 大连 116600;
    2. 大连民族大学环境与资源学院, 大连 116600
杨湘黔(1996-),男,贵州铜仁人,硕士研究生,微生物发酵研究专业。E-mail:465455121@qq.com

收稿日期: 2020-06-13

  网络出版日期: 2021-01-18

基金资助

国家自然科学基金项目(31272584);国家重点研发项目(2016YFC050050302)

Development of Real-Time Fluorescent Quantitative PCR Detection Method for Bacillus amyloliquefaciens and Its Application in Fermented Soybean Meal

  • YANG Xiangqian ,
  • CUI Jingchun ,
  • ZENG Shixian ,
  • CHENG Li ,
  • ZHANG Kebin ,
  • HU Xiaohong ,
  • BAO Yajing
Expand
  • 1. College of Life Science, Dalian Minzu University, Dalian 116600, China;
    2. College of Environment and Resources Sciences, Dalian Minzu University, Dalian 116600, China

Received date: 2020-06-13

  Online published: 2021-01-18

摘要

本试验旨在通过快速定量不同发酵时期下发酵豆粕中解淀粉芽孢杆菌(Bacillus amyloliquefaciens)的数量,以解决豆粕发酵过程品质监控的瓶颈难题,建立解淀粉芽孢杆菌的实时荧光定量PCR方法。根据解淀粉芽孢杆菌DNA解旋酶A亚基(gyrA)基因及16S核糖体RNA(16S rRNA)基因的保守区设计出3对引物,利用常规PCR筛选出1对特异性引物,并以该引物的扩增产物构建的重组质粒作为标准品,建立实时荧光定量PCR方法,并对该方法进行特异性、灵敏性、重复性检验,核酸水平抗干扰验证及豆粕对检测敏感度的干扰验证,最后对发酵的豆粕样品进行定量检测。结果表明:1)以gyrA基因设计的引物构建的质粒标准品建立的实时荧光定量PCR方法具有良好的特异性;2)该方法检测解淀粉芽孢杆菌核酸和菌液的最低检测限分别为102 copies/μL和103 CFU/mL;3)该方法组内变异系数在0.76%~3.27%,组间变异系数在0.34%~1.88%,均低于5%,说明重复性良好;4)含有与不含副干酪乳杆菌核酸的解淀粉芽孢杆菌的Ct值无显著差异(P>0.05),说明该方法不受检样中其他微生物的核酸干扰;5)该方法对豆粕中解淀粉芽孢杆菌的检测限为104 CFU/mL,比纯菌液最低检测敏感度(103 CFU/mL)降低了1个数量级(但不影响该方法的实际检测应用)。解淀粉芽孢杆菌在不同发酵时期发酵豆粕样品中定量检测结果表明,发酵0 d解淀粉芽孢杆菌的数量为9.33×105 copies/g,发酵至5 d接种菌数量为4.16×108 copies/g。由此可见,本试验建立的解淀粉芽孢杆菌实时荧光定量PCR方法特异性强,灵敏度高,抗干扰能力强,可快速定量发酵豆粕中的解淀粉芽孢杆菌的数量。

本文引用格式

杨湘黔 , 崔京春 , 曾诗娴 , 成丽 , 张珂彬 , 胡晓红 , 鲍雅静 . 解淀粉芽孢杆菌实时荧光定量PCR测定方法的建立及其在豆粕发酵中的应用[J]. 动物营养学报, 2021 , 33(1) : 494 -505 . DOI: 10.3969/j.issn.1006-267x.2021.01.050

Abstract

A new real-time fluorescent quantitative PCR (qPCR) detection method for detection of the quantity of Bacillus amyloliquefaciens in fermented soybean meal at different fermentation stages was developed in our study to solve the bottleneck problem of quality monitoring in the fermentation process of soybean meal. Three pairs of primers were designed from the conservative region of gyrase subunit A (gryA) gene and 16S ribosomal RNA gene of B. amyloliquefaciens. A pair of specific primers were screened out by conventional PCR, and the recombinant plasmid constructed by the amplification products of the primers was used as the standard. Then a real-time fluorescent quantitative PCR method was established. The established method was assessed with respect to specificity, sensitivity and repeatability, and the level of nucleic acid anti-interference, interference of soybean meal detection sensitivity. Finally, it was applied to detection of the fermented soybean meal samples. The results showed as follows: 1) the real-time fluorescent quantitative PCR method based on plasmid standard constructed with primers designed by gyrA gene had good specificity; 2) the minimum detection limits of nucleic acid level and bacterial solution of B. amylolyquefaciens were 102 copies/μL and 103 CFU/mL, respectively; 3) the coefficient variation (CV) were 0.76% to 3.27% in the intragroup and 0.34% to 1.88% in the intergroup, all of which were lower than 5%, indicating good repeatability; 4) there was no significant difference in Ct value between B. amylolyquefaciens with and without nucleic acid of Lactobacillus paracasei (P>0.05), indicating that the method was not interfered by nucleic acid of other microorganisms in the sample; 5) the detection limit of this method for B. amylolyquefaciens in soybean meal was 104 CFU/mL, which was one order of magnitude lower than the lowest detection sensitivity (103 CFU/mL) of pure bacterial solution (but did not affect the actual detection application of this method). The results showed that the number of B. amylolyquefaciens was 9.33×105 copies/g on the first day of fermentation and 4.16×108 copies/g on the fifth day of fermentation. Comprehensively, the results indicate that the established qPCR method has good specificity, sensitivity, anti-interference ability, and it can rapidly quantify the B. amyloliquefaciens in fermented soybean meals.

参考文献

[1] 程友飞.微生物固态发酵豆粕及其致敏性研究[D].硕士学位论文.南昌:南昌大学,2016:1-9. CHEN Y F.Study on the preparation and allergenicity of soybean meal by microbial solid state fermentation[D].Masters's Thesis.Nanchang:Nanchang University,2016:1-9.(in Chinese)
[2] 于海涛,周智旋,陆文清.角蛋白酶水解豆粕的微生物多样性分析[J].微生物学通报,2019,46(4):729-740. YU H T, ZHOU Z X, LU W Q.Microbial diversity of soybean meal hydrolysate treated by keratinase[J].Microbiology China,2019,46(4):729-740.(in Chinese)
[3] 李莹,韩云胜,赵青余,等.豆粕与发酵豆粕中主要营养成分、抗营养因子及体外消化率的比较分析[J].中国饲料,2019(23):76-81. YI Y,HAN Y S,ZHAO Q Y,et al.Comparative analysis of main nutrients,anti-nutritional factors and in vitro digestibility between soybean meal and fermented soybean meal[J].China Feed,2009(23):76-81.(in Chinese)
[4] YE M,SUN L H,YANG R,et al.The optimization of fermentation conditions for producing cellulase of Bacillus amyloliquefaciens and its application to goose feed[J]. Royal Society Open Science,2017,4(10):171012.
[5] 王美玲,吴骏晨,朱赟程,等.解淀粉芽孢杆菌在动物生产中应用的研究进展[J].中国畜牧杂志,2017,53(2):19-23. WANG M L,WU J C,ZHU Y C,et al.Research progress on application of Bacillus amyloliquefaciens in animal production[J].Chinese Journal of Animal Science,2017,53(2):19-23.(in Chinese)
[6] 王卉,游成真,秦宇轩,等.解淀粉芽孢杆菌L-S60生物学特性及其固态发酵工艺研究[J].中国农业大学学报,2016,21(9):133-142. WANG H,YOU C Z,QIN Y X,et al.The biological characteristics and solid-state fermentation of Bacillus amyloliquefaciens L-S60[J].Journal of China Agricultural University,2016,21(9):133-142.(in Chinese)
[7] 戴秀华,张荣胜,陈志谊.解淀粉芽胞杆菌Lx-11生物学特性研究[J].中国生物防治学报,2014,30(4):573-581. DAI X H,ZHANG R S,CHEN Z Y.The biological characterization of Bacillus amyloliquefaciens Lx-11[J].Chinese Journal of Biological Control,2014,30(4):573-581.(in Chinese)
[8] 陈洁梅,张灿辉,艾田.解淀粉芽孢杆菌KN-BL-1及其发酵豆粕产抗菌肽类物质的研究[J].中国生物工程杂志,2014,34(10):61-66. CHEN J M,ZHANG C H,AI T.Study of the antibacterial peptides produced by Bacillus amyloliquefaciens KN-BL-1 and its fermented soybean meal[J].China Biotechnology,2014,34(10):61-66.(in Chinese)
[9] SUPRIYATI,HARYATI T,SUSANTI T,et al.Nutritional value of rice bran fermented by Bacillus amyloliquefaciens and humic substances and its utilization as a feed ingredient for broiler chickens[J].Asian-Australasian Journal of Animal Sciences (AJAS),2015,28(2):231-238.
[10] CHI C H,CHO S J.Improvement of bioactivity of soybean meal by solid-state fermentation with Bacillus amyloliquefaciens versus Lactobacillus spp. and Saccharomyces cerevisiae[J].LWT-Food Science and Technology,2016,68:619-625.
[11] 付文娟,杨亚晋,王庆,等.高产蛋白酶菌株的筛选及其提高发酵豆粕肽含量效果研究[J].中国畜牧杂志,2013,49(23):41-46. FU W J, YANG Y J,WANG Q, et al. Screening of a new Bacillus which produces high protease and study on its peptide promoting effect on fermented soybean meal[J].Chinese Journal of Animal Science,2013,49(23):41-46. (in Chinese)
[12] 石俭.玉米芯发酵饲料的研制及其对兔、鸭饲喂效果的研究[D].硕士学位论文.保定:河北农业大学,2013:38-51. SHI J.Study on preparation of corncob fermentation feed and its feeding effect in rabbit,duck[D].Masters's Thesis.Baoding:Agricultural University of Hebei,2013:38-51.(in Chinese)
[13] 王毕英,王洪丽,刘彦民.微生态制剂活菌数方法研究进展[J].农产品加工,2018(24):77-79. WANG B Y,WANG H L,LIU Y M.Advances in methods of living bacteria count for microecological agents[J].Farm Products Processing,2018(24):77-79. (in Chinese)
[14] MARTÍNEZ-BLANCH J F,SÁNCHEZ G,GARAY E,et al.Development of a real-time PCR assay for detection and quantification of enterotoxigenic members of Bacillus cereus group in food samples[J].International Journal of Food Microbiology,2009,135(1):15-21.  
[15] DING T,SUO Y J,ZHANG Z H,et al.A multiplex RT-PCR assay for S. aureus,L. monocytogenes,and Salmonella spp. detection in raw milk with pre-enrichment[J].Frontiers in Microbiology,2017,8:989.
[16] ZHAO X H,ZHONG J L,WEI C J,et al.Current perspectives on viable but non-culturable state in foodborne pathogens[J].Frontiers in Microbiology,2017,8:580.
[17] YANG J,ZHANG N N,LV J,et al.Comparing the performance of conventional PCR,RTQ-PCR,and droplet digital PCR assays in detection of Shigella[J].Molecular and Cellular Probes,2020,51:101531.
[18] 李天芝,于新友,莫玲.基于16S rRNA基因的枯草芽孢杆菌PCR快速检测方法的建立[J].广东畜牧兽医科技,2016,41(1):30-33. LI T Z,YU X Y, MO L.Establishment and application of 16S rRNA gene-based PCR assay for detection of Bacillus suhtilis[J].Guangdong Journal of Animal and Veterinary Science,2016,41(1):30-33. (in Chinese)
[19] 孙晓棠,龙良鲲,崔汝强,等.利用PCR-DGGE技术快速检测鉴定饲用微生物[J].华南农业大学学报,2010,31(4):72-75. SUN X T,LONG L K,CUI R Q,et al.Detection and identification of direct fed microbials by PCR-DGGE[J].Journal of South China Agricultural University,2010,31(4):72-75. (in Chinese)
[20] YONG X Y,CUI Y Q,CHEN L H,et al.Dynamics of bacterial communities during solid-state fermentation using agro-industrial wastes to produce poly-γ-glutamic acid,revealed by real-time PCR and denaturing gradient gel electrophoresis (DGGE)[J].Applied Microbiology and Biotechnology,2011,92(4):717-725.  
[21] FERNÁNDEZ-ÁLVAREZ C,GONZÁLEZ S F,SANTOS Y.Quantitative PCR coupled with melting curve analysis for rapid detection and quantification of Tenacibaculum maritimum in fish and environmental samples[J].Aquaculture,2019,498:289-296.
[22] 郭佳佳,王立元,翁美芝,等.半夏曲中4种优势微生物的荧光定量PCR方法的建立[J].中草药,2017,48(24):5130-5135. GUO J J,WANG L Y,WENG M Z,et al.Establishment of fluorescent quantitative PCR method for four dominant microorganisms in Rhizoma Pinelliae fermentata[J].Chinese Traditional and Herbal Drugs,2017,48(24):5130-5135. (in Chinese)
[23] 程海星,郭月英,任霆,等.实时荧光定量PCR技术原理及在食品检测中的应用[J].食品与发酵工业,2015,41(3):243-247. CHENG H X,GUO Y Y,REN T,et al.Principle and application of fluorogenic real-time PCR in food detection[J].Food and Fermentation Industries,2015,41(3):243-247. (in Chinese)
[24] 吕旭聪,刘志彬,张雯,等.红曲黄酒传统酿造过程中优势细菌活菌检测方法的构建及应用[J].中国食品学报,2018,18(7):210-219. LV X C,LIU Z B,ZHANG W,et al.Construction and application of detection method for viable dominant bacteria during traditional brewing of Hongqu glutinous rice wine[J].Journal of Chinese Institute of Food Science and Technology,2018,18(7):210-219. (in Chinese)
[25] ROONEY A P,PRICE N P J,EHRHARDT C,et al.Phylogeny and molecular taxonomy of the Bacillus subtilis species complex and description of Bacillus subtilis subsp. inaquosorum subsp. nov.[J].International Journal of Systematic and Evolutionary Microbiology,2009,59(10):2429-2436.  
[26] 王琼,唐俊妮,汤承,等.一种采用微波炉加热快速提取细菌DNA用于PCR扩增的方法[J].西南民族大学学报(自然科学版),2015,41(2):150-155. WANG Q,TANG J N,TANG C,et al.Rapid method with microwave oven heating for bacterial DNA extraction applied to PCR amplification[J].Journal of Southwest University for Nationalities (Natural Science Edition),2015,41(2):150-155. (in Chinese)
[27] 巨向红,叶小妹,张金燕,等.一株枯草芽孢杆菌的饲料学特性研究[J].中国草食动物科学,2015,35(4):32-35,39. JU X H,YE X M,ZHANG J Y,et al.Study on the feed performance of a strain of Bacillus subtilis[J].China Herbivore Science,2015,35(4):32-35,39. (in Chinese)
[28] 张明,董玲.饲料微生物添加剂——地衣芽孢杆菌检验方法验证初探[J].饲料工业,2019,40(13):58-61. ZHANG M,DONG L.Validation of the test method for microbiological additive of feed Bacillus licheniformis[J].Feed Industry Magazine,2019,40(13):58-61. (in Chinese)
[29] WANG L T,LEE F L,TAI C J,et al.Bacillus velezensis is a later heterotypic synonym of Bacillus amyloliquefaciens[J].International Journal of Systematic and Evolutionary Microbiology,2008,58(Pt 3):671-675.
[30] 严婉荣,肖敏,陈圆,等.芽孢杆菌基本特征、16S rRNA对比分析及特异性基因挖掘[J].基因组学与应用生物学,2017,36(11):4686-4692. YAN W R,XIAO M,CHEN Y,et al.Comparative analysis between basic characteristics and 16S rRNA,and specific gene discovery of Bacillus[J].Genomics and Applied Biology,2017,36(11):4686-4692. (in Chinese)
[31] CHUN J,BAE K S.Phylogenetic analysis of Bacillus subtilis and related taxa based on partial gyrA gene sequences[J].Antonie van Leeuwenhoek,2000,78(2):123-127.  
[32] 曹凤明,杨小红,马鸣超,等.枯草芽孢杆菌近缘种群鉴定方法研究进展[J].微生物学通报,2014,41(5):968-974. CAO F M,YANG X H,MA M C,et al.Advances in the identification of Bacillus subtilis and closely related species[J].Microbiology China,2014,41(5):968-974. (in Chinese)
[33] YONG X Y,ZHANG R F,ZHANG N,et al.Development of a specific real-time PCR assay targeting the poly-γ-glutamic acid synthesis gene,pgsB,for the quantification of Bacillus amyloliquefaciens in solid-state fermentation[J].Bioresource Technology,2013,129:477-484.
[34] 夏雪娟,郑炯,叶秀娟,等.实时荧光定量PCR技术监测腌制麻竹笋中乳酸乳球菌动态变化[J].食品科学,2016,37(4):88-92. XIA X J,ZHENG J,YE X J,et al.Detection of Lactococcus lactis in pickled Ma bamboo shoots by quantitative real-time PCR[J].Food Science,2016,37(4):88-92.(in Chinese)
[35] 王梅,谢全喜,侯楠楠,等.三种益生菌发酵剂固态发酵对豆粕营养品质的影响[J].中国酿造,2020,39(2):115-119. WANG M,XIE Q X,HOU N N,et al.Effects of solid-state fermentation of three probiotic fermentation starters on the nutritional quality of soybean meal[J].China Brewing,2020,39(2):115-119. (in Chinese)
文章导航

/